Fueled vs Electric Cars: The Great Race Begins

AlgenolBioreactorsCPV

The amazing success of the Tesla model S proves that electric cars may have a chance of replacing liquid fueled vehicles in the long run. Skeptics point out that most of our electric power today comes from coal, which is dirty and inefficient. We must change to clean, renewable energy sources but is that really practical? The Tesla has proven that we can use photovoltaic solar power to recharge pure electric cars. Let’s calculate how much land is needed to renewably fuel a car using several possible electrical and biofuel approaches.

I recently purchased a Chevy Volt plug-in hybrid car. It is the perfect laboratory for this experiment because it can run on pure electricity or as a gasoline hybrid. In the electric mode it can go 38 miles on a 10.8 kilowatt-hour recharge. That’s 3.5 miles per kilowatt hour. Allowing for power transmission and charging losses, let’s use 3 mi/kWh. I will compare the land use efficiency of several real approaches to renewable power using both liquid fuel and electricity. We will calculate the number of miles per year that can be driven using an acre of land to produce the power. We can then compare the miles/year/acre numbers for some real-world renewable energy approaches.

Let’s start with the most efficient first, a concentrating photovoltaic (CPV) plant in Colorado. Amonix’s 180 acreAlamosa Solar plant will generate an estimated 76,000,000 kilowatt-hours of electricity per year. Dividing by 180 acres we get 422,000 KWh/yr/acre. Since we can drive three miles on a kilowatt-hour, we find that we can drive 1,266,000 miles per year per acre. That’s pretty encouraging!

CPV uses an array of magnifying glasses to concentrate the sunlight onto tiny photovoltaic chips. This only works well under clear sunny skies. In areas with many cloudy days, we would use fixed photovoltaic panels that can also capture diffuse light from cloudy skies. For example, the 100-acre Jacksonville solar plant in Florida generates 243,000 kilowatt-hours per year per acre. Multiplying by three, that’s enough to drive 729,000 miles/year/acre.

Wind power is another approach. The Horse Hollow Wind Energy Center in Texas generates 55,000 kWh/year/acre, enough to drive 165,000 miles/year/acre. Wind can be combined with solar on the same land and can produce almost twice as much at sea where winds blow steadily.

Liquid fuel can also power cars but the engine is typically about one third as efficient as electric drive. (My Chevy Volt is EPA rated at 37 mpg with 91 Octane gasoline which has 33.56 KWh/gal. 37/33.56 = 1.1 miles/KWh.) The best efficiency biofuel operation I know of is a pilot plant in Florida run by Algenol. They grow a genetically altered cyanobacteria (algae) that “sweats” ethanol in large, soft plastic tubes (see photo above). They claim to have produced 9,000 gallons/acre of ethanol in this pilot plant. Since ethanol has only 72 percent of the energy content of 91 octane gas, the Volt’s engine would probably get only about 26 mpg, which would be enough to drive 26×9,000 = 234,000 miles/year/acre.

Sugar Cane ethanol powers many of the cars in Brazil. It produces about 600 gallons per year per acre so you can drive 26×600 = 15,600 miles/year/acre.

Corn ethanol has been heavily subsidized so it is really available in great quantities but it makes very poor use of the land and a lot of water and fuel is used to grow it. It typically yields about 400 gallons per acre which translates to 10,200 miles/acre/year.

Palm oil diesel produces about 500 gallons/year/acre in tropical climates. Palm oil oil has 20 percent higher energy content than 91 octane gasoline so let’s assume 43 miles per gallon. 43×500 = 21,500 miles/year/acre.

Soy diesel yields about 57 gallons/year/acre so 47×57 = 2,679 miles/year/acre.

To summarize, here are the results, arranged in order of land use efficiency, with an additional column showing the acres needed to support one car based on 13,476 average miles driven per year according to the FHA:

Concentrated PV solar electric    1,266,000 miles/year/acre      1/94 acres/car

PV panels solar electric                   729,000                                    1/54

Algenol, Joule algae ethanol           234,000                                    1/17

Wind power electric                          165,000                                    1/12

Palm oil diesel fuel                              21,500                                     1/2

Sugar cane ethanol                             15,600                                    .86

Corn ethanol fuel                                  10,200                                    1.32

Soy diesel fuel                                        2,679                                     5

Though solar electric is the clear winner based on land use, biofuels are still in the race (particularly if commercial scale) designer algae becomes a reality. Biofuels have a gigantic advantage in remote areas because no power lines are needed. The liquid fuel can simply be picked up and delivered by trucks and ships. High-capacity power lines are very expensive to build and are seldom found in remote, tropical areas where land is cheap.

The existing sources of biofuels from soy and corn are an embarrassing result of political influence and heavy subsidies. We must stop letting politicians make technical choices!

Palm oil is a productive source of biofuel. Malaysia has 12 million acres in cultivation but many of the new sources are developed by burning peat and clearing jungle habitat. This is a boom for Indonesia and Malaysia but countries who burn coal and have already cleared their wilderness are hypocritically protesting. Oil palms are not the problem. They are guilty only of being very productive. Peat is the precursor to coal. Perhaps it can be sold as fuel as it is in Ireland. In the long run palm oil could be an almost carbon neutral source of energy that is far better than petroleum or coal. But more productive crops such as Algenol’s algae could greatly improve the efficiency of land use.

The yields for algae can potentially be even higher than shown on the table. Another algae startup promising even higher output is Joule Unlimited. They have predicted ethanol production of 25,000 gallons/year/acre and also direct production of biodiesel using another algae strain. Algae has been difficult to tame, but it has great promise for remote, sunny areas where land is cheap. Salt water or polluted water can be used and fresh water is distilled out in the process. Most growing plants waste large amounts of energy building supporting structures but algae can just float in water.

Electric cars are now my favored bet in the horserace between electric and fuel power. History has shown that progress in electronics generally outruns everything else. Solar photovoltaic power is progressing at its usual breathtaking pace. Soitec is already working on a next generation CPV design that will use four-layer cells with four different semiconductor materials stacked to capture a very wide bandwidth of light. The efficiency of this chip is an amazing 43.6 percent, which should make it possible to increase the numbers on the table above even further.

It will be an exciting race and I’m ready for whatever happens. When my Volt switches over to fuel mode, it still drives the same but the feeling I get is much nicer as I drive past the gas stations in electric mode.

Source: REW

 

About Ritesh Pothan

Ritesh Pothan, is an accomplished speaker and visionary in the Solar Energy space in India. Ritesh is from an Engineering Background with a Master’s Degree in Technology and had spent more than a decade as the Infrastructure Head for a public limited company with the last 9 years dedicated to Solar and Renewable Energy. He also runs the 2 largest India focused renewable energy groups on LinkedIn - Solar - India and Renewables - India
This entry was posted in Electric and Hybrid Vehicles and tagged , , , , , , , , , , . Bookmark the permalink.

One Response to Fueled vs Electric Cars: The Great Race Begins

  1. Pingback: 13 Major Clean Energy Breakthroughs Of 2013 | Natural Group

Comments are closed.